KENDALL CO -- POLYKEN 929 PRIMER  -- 8040-00F025500
<pre>=====================  Product Identification  =====================

Product ID:POLYKEN 929 PRIMER
MSDS Date:01/01/1987
FSC:8040
NIIN:00F025500
=== Responsible Party ===
Company Name:KENDALL CO
Address:1 FEDERAL ST
City:BOSTON
State:MA
ZIP:02101
Country:US
Info Phone Num:617-423-2000
Emergency Phone Num:617-423-2000
CAGE:97327
=== Contractor Identification ===
Company Name:KENDALL CO
Address:1 FEDERAL ST
Box:City:BOSTON
State:MA
ZIP:02101
Country:US
Phone:617-423-2000
CAGE:97327

=============  Composition/Information on Ingredients  =============

Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (CHLOROTHENE NU),
    AEROTHANE TT, CHLOROTHENE
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 87%
Other REC Limits:200 PPM (MFG)
OSHA PEL:350 PPM
ACGIH TLV:1910 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1

Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 3%
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:RUBBER

Ingred Name:POLYMERS (SYNTHETIC RESIN)

=====================  Hazards Identification  =====================

Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:INHALATION: SLIGHT IRRITATION TO
    MUCOUS MEMBRANES. EYES: SLIGHT IRRITATION. INGESTION: VOMITING.
    ASPIRATION MAY OCCUR DURING SPONTANEOUS VOMITING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHES, DIZZINESS, NAUSEA, &
    LOSS OF CONSCIOUSNESS. SKIN: DEFATTING & DRYING, WHICH MAY RESULT
    IN IRRITATION & DERMATITIS.

=======================  First Aid Measures  =======================

First Aid:INHALATION: REMOVE TO FRESH AIR & PROVIDE OXYGEN IF BREATHING
    IS DIFFICULT. GIVE ARTIFICIAL RESPIRATION IF NECESSARY. SKIN: FLUSH
    W/WATER FOLLOWED BY WASHING W/SOAP & WATER. EYES: FLUSH W/WATER FOR
    15	MINS. INGESTION: DON'T INDUCE VOMITING. IF VOMITING OCCURS
    SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID
    INTO LUNGS. OBTAIN MEDICAL ATTENTION IN ALL CASES.

=====================  Fire Fighting Measures  =====================

Flash Point Method:PMCC
Flash Point:>140F
Lower Limits:4.1%
Upper Limits:10.5%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, OR WATER FOG/SPRAY. DON'T
    USE DIRECT HOSE STREAM.
Fire Fighting Procedures:ISOLATE HAZARD AREA FROM UNNECESSARY PEOPLE.
    WEAR SCBA/FULL PROTECTIVE CLOTHING. COOL SURROUNDING AREA/EXPOSED
    CONTAINERS W/WATER. AVOID FUME/VAPOR INHALATION.

==================  Accidental Release Measures  ==================

Spill Release Procedures:ELIMINATE IGNITION SOURCE. GROUND EQUIPMENT TO
    PREVENT SPARKING. EVACUATE & VENTILATE AREA/WEAR PROTECTION.
    DIKE/REMOVE W/VACUUM TRUCK/PUMP TO STORAGE VESSEL. SOAK UP
    W/CLAY/SAND/OTHER SUITABLE MATERI AL. FLUSH W/WATER. PLACE IN
    LEAK-PROOF CONTAINER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:DON'T HANDLE OR STORE NEAR HEAT,
    SPARKS, FLAME, OR STRONG OXIDANTS. STORE IN ADEQUATE VENTILATION.
    (EQUIVALENT TO OUTDOORS)
Other Precautions:AVOID INHALATION OF VAPORS OR FUMES. AVOID CONTACT
    W/SKIN & EYES. NO SMOKING.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF THERE IS A POSSIBILITY THAT EXPOSURE MAY OR
    DOES EXCEED OSHA EXPOSURE LIMITS, USE NIOSH-APPROVED RESPIRATORS.
Ventilation:USE EXPLOSION-PROOF VENTILATION.
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:CHEMICAL GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING/SHOES
    BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:172-173F
Vapor Pres:113
Vapor Density:4.9
Spec Gravity:1.204
Evaporation Rate &amp; Reference:(N-BU = 1): 1.37
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK LIQUID W/CHLORINATED SOLVENT ODOR.
Percent Volatiles by Volume:89%

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN,
    SODIUM HYPOCHLORITE & CALCIUM HYPOCHORITE
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, & OTHER IGNITION
    SOURCES
Hazardous Decomposition Products:CO, UNIDENTIFIED ORGANIC COMPOUNDS

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
    FEDERAL REGULATIONS. DON'T ALLOW MATERIAL TO ENTER SEWERS OR ANY
    COURSES LEADING TO SURFACE WATERS. DISPOSE ACCORDING TO RCRA
    REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.